BMW Corsa Performance Exhaust Systems for BMW 3 Series E92 (2007-2013)

Clear BMW chassis
CORSA is one of the largest automotive and high-end marine exhaust tuning companies in the USA with engineering and manufacturing facilities in Ohio and a patented, proprietary technology called Reflective Sound Cancellation™ (RSC, for short). CORSA consults to General Motors, Ford and Daimler-Chrysler and carries the title of "official licensed product" on its GM aftermarket exhaust systems.

The result of the CORSA's partnership and extensive research and development on the BMW 3 and 5 Series, is the new dronefree RSC™ exhaust system, delivering a pleasant sound at idle and cruise, and a muscular roar at high rpm. CORSA tuned this system specifically to counter drone. Sound pressure waves are reflected within the muffler case and unwanted noise frequencies are cancelled through patented Refective Sound Cancellation™ technology. Their straight-through design coupled with RSC™ noise cancellation technology allows them to tune out the undesirable low frequencies that cause droning, while reducing back pressure. A reduction in back pressure allows the engine to produce more horsepower and torque. The end result is a tuned muffler that produces the best sound and performance possible.

E9X 335i/xi Turner/Corsa TrackSport 3.5" Exhaust System
Turner Motorsport - Corporate Logo
T#:338613
Part#: COR14861-
Available
Starting at $2,099.95
Starting at $2,099.95

  • Aggressive, Throaty Sound
  • No Highway Drone!
  • Full exhaust from downpipe
  • Massive 3.5" (89mm) Exhaust Piping
  • Made in the USA
  • Lifetime Warranty


The TURNER Corsa exhaust for the E90, E92 335i and 335xi is a full cat-back system in a super large 3.5" tubing diameter. With a turbo engine like the N54 and N55 larger piping in the exhaust helps the turbo to push exhaust gases. The turbos become more efficient and are working less hard which helps with their longevity. The Corsa cat-back flows 35% better than the stock system! And a noticeable power boost comes with it too! This system bolts to the downpipes just like the factory exhaust, and includes a center resonator and two large rear mufflers. This system has been tuned to deliver a barking exhaust note at full throttle while remaining civilized and toned at moderate throttle openings and no drone at highway cruise! This exhaust features a single round 4.0" tip per side in either polished stainless or diamond black finish. The cat-back layout and extra large piping contribute to an 14hp gain on the dyno.

This exhaust is built completely from T-304 stainless steel, including the flex pipe, resonator, and mufflers. Factory style flanges allow the full system to mount to the stock, or aftermarket, downpipes and all of the factory hangers are re-used. Shims for the center transmission reinforcement complete this easy-to-install layout. The large, mandrel-bent tubing diameter is the best for flow and reducing backpressure on the turbo wheels. And thanks to patented Reflective Sound Cancellation (RSC), exhaust drone is all but eliminated.

Reflective Sound-Cancellation (RSC) technology - This technology is a non-electrical noise control system, where engine sound (pressure) waves are reflected in passages inside the muffler 180 degrees out of phase to cancel out unwanted sound waves. The result is a "tuned" muffler that "cleans up" the noise without eliminating the pure sound of power associated with a high-performance vehicle. Using the Corsa technology, the stainless steel Corsa Performance line of mufflers are tuned to eliminate passenger cabin resonance and produce just the "right" sound. The result is quieter cruising with an awe-inspiring roar at full throttle. This system is amazingly quiet during normal cruising, due to the "no drone" RSC technology, yet still has an aggressive presence and full sound while under throttle. This makes for ideal sound for those that want an aggressive "roar" while driving hard, yet still want a more discrete lower volume for normal cruising.

This is a full exhaust system, from the downpipes back. You can remove your stock exhaust as one long piece which greatly simplifies the install. The Corsa system uses all of the factory hangers and gaskets. Detailed photographic instructions are included. This system is 100% Made in the USA and carries a lifetime warranty from the manufacturer. For 2007-2010 N54 models, a waiver of emissions compliance is required because this deletes the secondary catalytic converters but will have no effect on "Check Engine" warning lights.

This exhaust system eliminates the rear catalytic converters on N54 engined cars. This part alters or deletes the emissions equipment on your car, and may not meet emissions standards in all states. Because of this, we require a waiver of emissions compliance to be signed and sent in to TMS. You can download the waiver here.


Sound Clips:


E90 335i Corsa Full Exhaust
revving and exterior driving



Exhaust Specs:

section:complete exhaust

connects to:downpipes

tip style:4.0" dual round; stainless or black (polished)

material:T304 stainless steel


This Corsa Exhaust fits the following BMWs:
2007-2011 E90 BMW 335i 335xi 335i xDrive - Sedan
2007-2013 E92 BMW 335i 335is 335xi 335i xDrive - Coupe
2007-2012 E93 BMW 335i 335is - Convertible

E9X M3 Turner/Corsa Sport Exhaust System
Turner Motorsport - Corporate Logo
T#:338612
Part#: COR1456X
Direct Ship
Starting at $1,755.00
Starting at $1,755.00

  • Aggressive, Throaty Sound
  • No Highway Drone!
  • Full Cat-Back
  • Made in the USA
  • Lifetime Warranty


Turner Corsa Performance T-304 stainless exhaust system for 2008, 2009 and newer E90/E92/E93 M3 (sedan, coupe & convertible). Features mandrel-bent tubing, polished quad 3" tips (double-walled, angle cut and staggered), and drone-free quiet-cruising, thanks to patented Reflective Sound-Cancellation (RSC) technology. This is a drone-free exhaust system, delivering a pleasant sound at idle and cruise and a muscular roar at high rpm.

How is this accomplished? The RSC technology is a non-electrical noise control system without the complication of incorporating the use of electronics or speakers. Essentially, engine sound (pressure) waves are reflected in passages inside the muffler 180 degrees out of phase to cancel out unwanted sound waves. The result is a "tuned" muffler that "cleans up" the noise without eliminating the pure sound of power associated with a high-performance vehicle. Using the Corsa technology, the stainless steel mufflers are tuned to eliminate passenger cabin resonance and produce just the "right" sound. The result is quieter cruising with an awe-inspiring roar at full throttle. This system is amazingly quiet during normal cruising, due to the "no drone" RSC technology, yet still has an aggressive presence and full sound while under throttle. This gives your E90/E92 M3 an ideal sound for those that want an aggressive "roar" while driving hard, yet still want a more discrete lower volume for normal cruising. (Please check out the video below for a sound sample on a 2008 M3 coupe).

As well as the tuned sound and drone eliminating sound, the mufflers on this E90/E92 M3 system use a straight-thru flow design for maximum flow and the least amount of restriction. Decreasing the restrictive back-pressure results in more horse power and torque, as well as the inspired sound this system creates for your M3's 4.0 liter V8 engine. There is no effect whatsoever on emissions, as this system does not replace or inhibit the your M3's factory catalytic converters, so there will not be any "Check Engine" warning lights. Emissions-legal in all 50 states. Made 100% in the USA, this exhaust features a lifetime warranty from the manufacturer. Includes full installation instructions, with detailed photos for easy and straight forward installation.

Sound Clips:


E92 M3 Corsa Exhaust
stock vs. Corsa comparisons
E92 M3 Corsa Exhaust
accelerating, in-car driving



Exhaust Specs:

section:rear muffler

connects to:factory resonator/cat exhaust section

tip style:3" quad round; polished stainless or black (polished)

material:T304 stainless steel



This item fits the following BMWs:
2008-2011 E90 BMW M3 Sedan
2008-2012 E92 BMW M3 Coupe
2008-2012 E93 BMW M3 Convertible

E9X 335i/xi Turner/Corsa Axle-Back Sport Mufflers
Turner Motorsport - Corporate Logo
T#:338609
Part#: COR14561X
Direct Ship
Starting at $1,049.00
Starting at $1,049.00

  • Aggressive, Throaty Sound
  • No Highway Drone!
  • Rear Muffler Section - a bargain compared to a full system
  • Made in the USA
  • Lifetime Warranty


The Turner Corsa Performance stainless mufflers for E90/E92 335i and 335xi features mandrel-bent tubing, polished 4" tips, a muscular roar at high rpm, and drone-free quiet-cruising. The Corsa 335 mufflers produce a sporty but restrained exhaust note, not overpowering and not intrusive. The Corsa gives a 335 the muscular sound that a tuned performance car should have. Each muffler uses a straight-thru design for maximum flow, resulting in more horsepower and torque. But Corsa's Reflective Sound Cancellation technology eliminates any drone at highway speeds! This system is just the rear mufflers, after the stock resonator, so you get most of the sound of a full exhaust but at much less cost.

Reflective Sound-Cancellation (RSC) technology - This feature is a patented non-electrical noise control system, where engine sound (pressure) waves are reflected in passages inside the muffler 180 degrees out of phase to cancel out unwanted sound waves. The result is a tuned muffler that "cleans up" the noise without eliminating the pure sound of power associated with a high-performance vehicle. Using the Corsa technology, the stainless steel mufflers are tuned to eliminate passenger cabin resonance and produce just the "right" sound. The result is quieter cruising with an awe-inspiring roar at full throttle. This system is amazingly quiet during normal cruising, due to the "no drone" RSC technology, yet still has an aggressive presence and full sound while under throttle. This makes for ideal sound for those that want an aggressive "roar" while driving hard, yet still want a more discrete lower volume for normal cruising.

This is an axle-back system, which replaces only the rear mufflers of the stock 335i/xi exhaust. It's very easy and straightforward to install and the rest of the exhaust can remain on the car (the original mufflers are cut from the exhaust). Detailed photographic instructions are included. This system is 100% Made in the USA and carries a lifetime warranty from the manufacturer. This exhaust is emissions legal in all 50 states (no effect whatsoever on emissions, and no "Check Engine" warning lights).

Sound Clips:


E92 335i Corsa Exhaust
revving, take off, interior
E90 335i Corsa Exhaust
revving and exterior driving



Exhaust Specs:

section:rear mufflers

connects to:stock exhaust section up to the rear axle

tip style:4.0" dual round; stainless or black (polished)

material:T304 stainless steel


This Corsa Exhaust fits the following BMWs:
2007-2013 E92 3 Series Coupe - 335i 335xi
2007-2012 E92 3 Series Convertible - 335i 335is


Select Vehicle

Category

  • Corsa Performance Exhaust Systems

Price

$
$