BMW Maintenance & Tune-Up Parts for BMW E39 M5 S62 5.0L

When changing your oil, you want to make sure you are using the best. Turner Motorsport now offers our premium Castrol TWS Oil service kits to ensure you are getting the best products available for your routine oil services. Everything included has been specifically picked to ensure high quality and outstanding wear protection. 

One of the most popular engine oil choices on the market today, Castrol Edge Professional TWS 10-60 engine oil is premium engine oil approved by BMW for use in a wide variety of engines such as the M30, S54, S85, and many more. In fact, this oil is the same oil that BMW uses for their performance engines from the factory. Thanks to its premium blend of synthetic oil and additives, this oil continues to provide protection under even the harshest conditions and is perfect for both street cars and cars that see occasional track use.

Specifications:

• SAE-10w60
• ACEA A3/B4
• API SN/CF
• VW 501 01/505 00
• Exclusive Approval for BMW M-Models

Included in this Kit:

• Castrol TWS 10w-60 Premium Oil - 7 Liters
• Engine Oil Drain Plug & Washer
• Premium Oil Filter

Don't up with the maintenance on your car is the smart thing to do. For one thing, it prevents costly repairs in the future. For another, your car performs better, making aftermarket upgrades more worthwhile. And a well-maintained car with complete service records can add substantially to a car's resale value. Our service packages for your M5 will ensure you get many more miles from your BMW muscle car.

The M5 is a special car in BMW's line-up and it takes special attention to maintain its lofty output. Looking after the M5's various needs and problem areas will reward you with a better M ownership experience and make your car stand out from less cared-for cars if/when it's time to sell. In addition to the normal maintenance items listed below, you may also want to check or replace the following:
+ fuel pump (especially if the car is hard to start or stumbles in the RPM range)
+ front (pre-cat) oxygen sensors
+ check valve cover gaskets, intake plenum seals, vacuum lines, and hoses for leaks
+ service or replace crankcase vent valve/oil separator system
+ VAN0S solenoid rebuild or replacement
+ have an engine oil analysis done annually. This will make it easier to spot internal engine wear, including rod bearing wear, as well as head gasket failure and coolant loss.
+ replace camshaft position sensors
+ secondary air pump system test or service
If you haven't read about the M5's carbon build-up issue, visit our write-up by clicking here.

This package can be configured any number of ways to ensure you get what you need for a full Inspection I, Inspection II, or any other major preventative maintenance service. Our parts are OE, OEM, or performance alternatives that we have been using since 1993 so you get top quality parts, first-rate service, and unbeatable expertise.
 

5,000 Mile Oil Service

(click to expand)

• engine oil change with filter, using OE BMW 5W30, BMW-Castrol 10W60, or Motul
• install or clean magnetic drain plug
• replace drain bolt crush washer
• reset oil service/maintenance light
• inspect and top off any other fluids

Annual Service

(click to expand)

• air filter cleaning or replacement
• airflow sensor/MAF cleaning
• engine oil analysis (to check for internal engine wear)
• A/C microfilter/cabin filter replacement
• brake fluid flush/bleeding
• top off power steering fluid
• wiper blade replacement
• lubricate door hinges and treat rubber door seals
• inspect M Mobility System and emergency tools
• inspect belts for cracking or stretching
• inspect intake boots and vacuum lines for cracks
• inspect brake system for pad wear, rotor wear, parking brake operation, and brake pedal pressure
• inspect bushings and ball joints for excess play/movement, especially the front thrust arm bushings and rear sway bar mounts
• ensure the cooling systems are functioning correctly (hoses and thermostat, thermostat housing, auxiliary fan, A/C system, etc)

30,000 Mile Major Service

(click to expand)

• engine oil change with filter, using OE BMW 5W30, BMW-Castrol 10W60, or Motul
• reset oil service/maintenance light
• air filter replacement or cleaning for aFe/K&N type
• fill and bleed cooling system
• transmission fluid change, using Red Line ATFD4 or Motul ATF
• differential fluid change, using Red Line 75/140 or Motul GearComp 75/140, or OEM oils
• brake fluid flush/bleeding
• fuel filter replacement
• engine and A/C serpentine belt replacement
• inspect belt roller pulleys (drag and rotation), main accessory pulleys (cracking), and belt tensioners
• complete chassis inspection, including: front control arms, tie rods, ball joints, wheel bearings, rear trailing arm bushings, rear upper shock mounts, rear subframe mounts, rear sway bar mounting tabs, axle shaft boots
• complete brake system test and inspection
• engine and transmission leak detection and diagnosis
• shifter linkage, driveshaft guibo, u-joint, CV joint, and center support bearing inspection
• exhast system inspection, including hanger replacement

60,000 Mile Major Service

(click to expand)

• spark plug replacement
• ignition coil and coil boot inspection and replacement
• engine oil change with filter, using OE BMW 5W30, BMW-Castrol 10W60, or Motul
• reset oil service/maintenance light
• air filter replacement or cleaning for aFe/K&N type
• fill and bleed cooling system
• transmission fluid change, using Red Line ATFD4 or Motul ATF
• differential fluid change, using Red Line 75/140 or Motul GearComp 75/140, or OEM oils
• brake fluid flush/bleeding
• fuel filter replacement
• engine and A/C serpentine belt replacement
• replace belt roller pulleys and belt tensioners
• inspect main accessory pulleys for cracks
• complete chassis inspection, including: front control arms, tie rods, ball joints, wheel bearings, rear arm bushings, rear shock mounts, rear subframe mounts, rear sway bar mounting tabs, axle shaft boots
• complete brake system test and inspection
• engine and transmission leak detection and diagnosis
• shifter linkage, driveshaft guibo, CV, and center support bearing inspection
• exhast system inspection, including hanger replacement

You may also want to pick up these other helpful items:

• replace your drain plug with a magnetic one
• Bentley Service Manual
• Peake Fault Code Scanner and Service Light Reset Tool
  
• This package fits the following BMWs:
  1998-2003 E39 BMW M5
  
  
  Put a check in the boxes next to the items you wish to order.

This is the sensor / sending unit that notifies the computer if your coolant level is low. When this fails, it can give a false indication of low coolant -- or worse, not inform you of a low coolant situation which could potential cause overheating. (Note: This sensor is also found in the windshield washer container, to alert the computer when you are low on washer fluid)

When doing any sort of repair or maintenance there is no replacement for genuine factory parts. Turner Motorsport carries the Genuine BMW brand with pride and has the parts you need to complete your next project with confidence.

This sensor also serves as the washer fluid level sensor on many models.

This fluid level sensor is found on the following BMWs:
1999-2005 E46 3 Series - 323i, 323Ci, 328i, 328Ci, 325i, 325ix, 325Ci, 330i, 330ix, 330Ci
2001-2006 E46 M3
2000-2003 E39 M5 Coolant Level Sensor only
2006-newer E90/E92 3 Series - 325i, 325xi, 328i, 328xi, 330i, 330xi, 335i, 335xi M3
2004-2009 E60 5 Series - 525i, 525xi, 528i, 528xi, 530i, 530xi, 545i, 550i, M5
2004-2009 E63/E64 6 Series - 645Ci, 650i, M6
2002-2009 E65/E66 7 Series - 745i, 745Li, 750i, 750Li, 760i, Alpina B7
2004-2009 X3 SAV - X3 2.5i, X3 3.0i, X3 3.0si
2000-2006 E53 X5 X5 3.0i X5 4.4i X5 4.6is X5 4.8is
2007+ E70 X5 X5 3.0si X5 4.8i X5 xDrive30i X5 xDrive48i X5M
2007+ E71 X6 X6 xDrive35i X6 xDrive50i X6M
2003-2009 Z4 Roadster/Coupe - Z4 2.5i, Z4 3.0i, Z4 3.0xi, MZ4 Roadster & Coupe
2000-2003 E52 Z8 Z8 Roadster - Coolant Level Sensor only